CAJUN SMOKED SAUSAGE RECIPE RECIPES

Steps:

• The most important thing is to use the right equipment and I would suggest the following: a 2-gallon cast iron Dutch oven, a high BTU gas stove, and a large stainless steel chef's spoon.
• Use high heat to preheat the Dutch oven and add the sausage. Using a chef's spoon or large spoon, constantly move the sausage from the bottom of the pot. Be careful not to burn the meat. (Normally I use Manda's sausage because it has little fat, however at this point you may want to drain off all of the excess grease to reduce the fat content from the dish.)
• Add the thigh meat and brown the chicken on all sides. Again use the spoon to scrape the meat from sticking and burning to the bottom of the pot. Browning the sausage and chicken meats should take 20 minutes. Be careful not to over cook the thigh meat to the point that it shreds.
• Lower the heat to medium and add the onions and garlic; saute for about 15 minutes or until the onions are very limp and "clear". Scrape the bottom of the pot to remove all the "graton". This is where the jambalaya gets its distinct brown color and taste.
• Add the tasso, thyme, basil and black and white pepper. Simmer over low heat for 10 minutes. This will give the seasonings time to release their oils and flavors.
• At this point the jambalaya concentrate can be transferred to smaller containers, cooled to room temperature, covered and refrigerated for future use. (This is what we do commercially; it allows the seasonings to marry.)
• When you are ready to cook the jambalaya, add the stock to the concentrate and bring to a rolling boil. Add the rice, reduce the heat to medium and gently break up the rice. Using the stainless steel paddle, continue to insure that the rice is not sticking to the bottom of the pot; this is very important!
• After about 5 minutes, fold in the parsley. Continue to scrape the pot to insure that no rice sticks to the bottom. When the jambalaya returns to a boil, reduce heat to the lowest possible setting and simmer, covered, for at least 25 minutes. Do not remove the cover while the rice is steaming.
• If Manda's brand sausage is not available, any lean smoked sausage can be substituted. You may have to remove any excess grease from the pot after frying down an unknown sausage.
• For a richer jambalaya substitute turkey stock for the chicken stock called for above.
• If no stocks are available, then chicken soup base can be used. Be careful with your seasoning, as bases are usually full of salt.
• Alternate Method:
• The jambalaya is best when served directly out of the cast iron pot. While the rice is steaming, the sausage and meat will have a tendency to float to the surface of the jambalaya. Therefore, after the rice has steamed for 25 minutes, use the paddle to gently fold in the meat and seasonings into the cooked rice. This should only be done once or twice, the rice will loose a lot of heat and the rice will break apart.
• Also note, I do not add salt to my jambalaya. This is because I like to use herbs, tasso and seasonings to satisfy the need for salt. I would suggest having the table set with salt shakers and a selection of hot pepper sauces.
• Plate Presentation:

Steps:

• Place the pork shoulder, celery, onion, garlic, bell pepper, and salt into a large pot. Cover with 2 inches of water, bring to a boil and then turn down the heat and simmer uncovered for 1 hour. After an hour, add the chicken liver to the pot and continue to cook for 45 more minutes or until the pork is tender.
• Strain the meat and vegetables, reserving the liquid. Finely dice the meat and vegetables with a knife, in a food processor or in a meat grinder set for a coarse grind. Once diced, place meat and vegetables in a bowl.
• Add to the bowl the cooked rice, jalapeños, thyme, oregano, paprika, green onions parsley, black pepper, and cayenne. Stir in 1 cup of the reserved cooking liquid and combine until the filling is moist and slightly sticky. If it appears too dry, add more of the reserved liquid. Taste and adjust seasonings, if needed.
• To stuff into casings for sausage, first rinse the outside of the casing and then place it in a bowl of water for 30 minutes to soften. Drain the soaking water and then rinse the inside of the casing by placing one end on the kitchen faucet, turn the water on low and allow it to flow through the casing. The casing will blow up like a balloon—this is fine.
• Lightly oil the stuffing horn on your sausage stuffer with vegetable oil. Tie a knot at one end of the casing. Take the other end and gently slide the entire casing onto the horn, leaving the knot plus an additional 4 inches hanging off the end of the horn.
• Place the filling into the feeder and push it through until it starts to fill the casing. Go slowly at first and note that you’ll need to massage the casing as the meat goes through it so it fills the casing evenly.
• Once you’ve filled the casing, to form links, pinch it every 5 inches and then twist it until it’s secure. You can then cut the casing to form individual sausages.
• To cook, poke holes into the casing then then poach in boiling water for 10 minutes. You can also grill or smoke the boudin.
• Alternatively, you can either serve the filling as a dressing, or you can roll it into walnut-sized balls, dip into finely crushed crackers and fry in 350 degree oil for 2 minutes or until brown to make boudin balls.