MAKING CANNOLI SHELLS RECIPES

Steps:

• Mix together flour, shortening, salt and sugar.
• Add enough wine to make a stiff but workable dough.
• Roll dough into a ball and let it stand for about 1 hour.
• Roll dough out 1/8 inch thick.
• Cut rolled dough into 5x5 inch squares.
• Place a cannoli tube across dough square on an angle (from top left corner to bottom right corner).
• Wrap one corner around the tube, then the other (which should overlap the first).
• Press together to seal seam.
• Fry in deep fat, one at a time, until deep golden brown.
• Carefully remove fried cannoli shell from tube.
• Cool completely before filling.
• ***Cannoli tubes are usually made from sheet aluminum and should be 8 inches long by 1 inch in diameter.

Steps:

• Three or more days in advance of making the cannoli shells set the ricotta in a colander inside of a large bowl.
• Scrape the ricotta into the colander and cover with plastic wrap.
• Let the ricotta drain in the refrigerator for two days, until it is dry.
• To make the dough for cannoli shells: In a small bowl put eggs.
• Beat eggs; add vanilla and ice water to eggs.
• In a large bowl, use your hands to combine the flour, sugar, salt, cocoa, and cinnamon.
• Add the shortening and mix until crumbly.
• Make well in dry mixture and add wet mixture.
• Using your hands mix together, if it is dry, add more ice water.
• Turn the dough out onto a lightly floured surface and knead until smooth and well blended, about 3 minutes.
• Shape the dough into a flattened ball.
• Cover with plastic wrap and let rest at room temperature for at least 30 to 60 minutes.
• Cut the dough into 4 pieces.
• Starting at the middle setting, run one of the pieces of dough through the rollers of a pasta machine or the dough can be rolled on a board with a rolling pin.
• Lightly dust the dough with flour as needed to keep the pieces from sticking.
• Continue to pass the dough through the machine until you reach the last or second to last setting.
• You might need to run the dough through the pasta machine three times.
• The dough needs to be thin-about the same thickness as construction paper; cut the dough into 4 1/2 inch circles. (Giovanna’s cannoli tubes are 6 inches long and 1 inch in diameter.).
• Continue rolling out the remaining dough.
• If you do not have enough cannoli tubes for all of the dough, lay the pieces of dough on sheets of plastic wrap and keep them covered until you are ready to use them.
• Put a rack in the bottom of a large heavy kettle that you plan on putting your peanut oil into so that your cannoli shells do not touch the bottom and burn. (Giovanna uses a restaurant kettle that is about 18 inches in diameter.).
• Pour about 2 inches of oil in a smaller kettle. Giovanna used 4 quarts but her kettle is huge!
• Heat oil until a deep frying thermometer shows 375 degrees.
• Oil the cannoli tubes by placing them in the hot oil then draining them in a metal bowl (you need the oil on the tube so that later the cannoli shell will slip off easily).
• Lay the dough circle flat, center the tube on it, bring left edge onto tube, dab it with egg white, bring up right side of dough circle, dab it with egg white, and roll the tube; do not press the dough. You do not want the dough to be too tight on the tube, or you will have difficulty later getting your cannoli off. Be careful not to stretch the dough or pull it tightly. Avoid, as best as possible, getting egg white on the tube, or the cannoli will stick to it.
• Repeat with the remaining dough.
• Carefully lower a few of the cannoli tubes into the hot oil. Do not crowd the pan.
• Fry the shells until golden, about 2 minutes, turning them so that they brown evenly.
• With tongs, remove the cannoli tubes, holding them straight up so that the oil flows back into the pan.
• Then drain the cannoli still on tube briefly in a metal bowl.
• While the cannoli shells are still hot, carefully slide the shells off the tubes by grasping each tube with a clean towel and gently twisting the cannoli shell off the tube with your other hand protected by an oven mitt or towel. On another work surface area, lay oilcloth or newspaper, topped with a large rack.
• When the cannoli shells are barely warm set them on top of the rack.
• It is important that the shells stay on the racks overnight.
• Repeat with the remaining dough.
• If you are reusing the cannoli tubes, let them cool before wrapping them in the dough; set aside.
• The cannoli shells can be made up to 2 months before serving if you drain them properly overnight, and store them in sealed containers in a cool, dry place, but not in a refrigerator.
• To make the ricotta cream, put the thoroughly dry ricotta in a large mixing bowl with a wire whip and blend until creamy.
• Add the confectioners’ sugar, granulated sugar, vanilla, and cinnamon oil; blend until smooth.
• Transfer to a bowl and stir in the chocolate pieces. Store the ricotta cream in the refrigerator for 48 hours. After 48 hours, serve and freeze the rest.
• Frozen ricotta cream can be defrosted in the refrigerator later.
• To assemble, use a knife to push the ricotta cream into the cannoli shell.
• Place the cannoli on a serving platter and sprinkle with confectioners’ sugar.
• Use within an hour.